| 利用玻璃化温度梯度制备天然橡胶类高阻尼弹性体材料 |
| Preparation of NR Type High Damping Elastomer Taking Advantage Tg Gradient |
| 投稿时间：2022-11-07 修订日期：2022-11-07 |
| DOI：10.12136/j.issn.1000-890X.2023.02.0083 |
| 中文关键词: 天然橡胶 环氧化天然橡胶 并用胶 玻璃化温度 梯度 阻尼弹性体 |
| 英文关键词: NR ENR blend Tg gradient damping elastomer |
| 基金项目:国家自然科学基金资助项目（51873065） |
|
| 摘要点击次数: 994 |
| 全文下载次数: 797 |
| 中文摘要: |
| 利用天然橡胶（NR）与环氧化天然橡胶（ENR）良好的相容性，以及不同环氧化程度的ENR的玻璃化温度（Tg）
梯度差异，选用NR和3种不同环氧化程度的ENR（ENR-25，环氧化程度为25%；ERN-40，环氧化程度为40%；ENR-50，环
氧化程度为50%）制得NR/ENR-25/ENR-40/ENR-50四元并用阻尼材料，研究由于NR和各ENR的Tg和用量差异产生的
阻尼加和效应对并用胶在室温及以上温度的阻尼温域的拓宽情况。结果表明，当NR/ENR-25/ENR-40/ENR-50并用比
为55/5/15/25，同时添加40份炭黑N330时，四元并用胶具有较好的综合性能，其有效阻尼温域（损耗因子大于0. 3）为66
℃（－15. 3～50. 7 ℃），拉伸强度可达17. 2 MPa，拉断伸长率为571%。 |
| 英文摘要: |
| Based on the good compatibility between natural rubber（NR） and epoxidized natural rubber
（ENR），and the gradient difference of glass transition temperature（Tg）of ENR with different epoxidation
degrees，NR and three ENRs（ENR-25，ENR-40 and ENR-50，with a epoxidation degree of 25%，40%,
and 50%，respectively） were selected to prepare a high damping quaternary blends. The damping addition
effect caused by the difference of Tg and the amount of NR and ENRs on the broadening of the damping
temperature range of the compound at room temperature and above was studied. The results showed that，
when the blending ratio of NR/ENR-25/ENR-40/ENR-50 was 55/5/15/25 and 40 phr carbon black N330
was added，the quaternary blend had better overall performance，and its effective damping temperature range
（loss factor greater than 0. 3） was 66 ℃（－15. 3～50. 7 ℃)，the tensile strength reached 17. 2 MPa，and the
elongation at break was 571%. |
|
|
查看全文
查看/发表评论 下载PDF阅读器 |
| 关闭 |
