多巴胺还原氧化石墨烯增强溴化丁基橡胶复合材料的性能研究 |
Study on Properties of BIIR Composites Reinforced by DA Reduced GO |
投稿时间:2021-04-03 修订日期:2021-04-14 |
DOI:10.12136/j.issn.1000-890X.2023.01.0003 |
中文关键词: 多巴胺 氧化石墨烯 溴化丁基橡胶 拉伸性能 耐溶剂性能 介电性能 |
英文关键词: DA GO BIIR tensile property solvent resistance dielectric properties |
基金项目:国家自然科学基金资助项目(51763006);广西自然科学基金创新团队项目(2019GXNSFGA245005) |
|
摘要点击次数: 815 |
全文下载次数: 1061 |
中文摘要: |
采用多巴胺(DA)对氧化石墨烯(GO)进行改性得到聚多巴胺改性石墨烯(PDA-rGO),通过溶液共混法制备PDA-rGO/溴化丁基橡胶(BIIR)复合材料,研究PDA-rGO用量对复合材料性能的影响。结果表明:DA的改性抑制了GO在BIIR基体中的堆叠团聚,并增强GO与BIIR基体间的界面相互作用;与BIIR胶料相比,PDA-rGO(用量0.5份)/BIIR复合材料的交联密度增大58%,对于甲苯的溶胀指数减小14%,拉伸强度增大40%,其综合性能最佳;在频率1 kHz下,PDA-rGO(用量0.5份)/BIIR复合材料的相对介电常数增大26%,其液敏元件对甲醇和丁酮的电容响应度显著增大,分别达到10.7和79.4,PDA-rGO/BIIR复合材料有望用于某些有机溶剂的鉴别。 |
英文摘要: |
Abstract:Polydopamine-modified graphene(PDA-rGO) was obtained by modifying graphene oxide
(GO) with dopamine(DA). The PDA-rGO/bromobutyl rubber(BIIR) composites were prepared by
solution blending method,and the effect of the amount of PDA-rGO on the properties of the composites was
studied. The results showed that the modification of DA inhibited the stacking and agglomeration of GO in
the BIIR matrix and enhanced the interfacial interaction between GO and BIIR matrix. Compared with the
BIIR compound,the crosslinking density of the PDA-rGO(0. 5 phr)/BIIR composites increased by 58%,
the swelling index of toluene decreased by 14%,the tensile strength increased by 40%,and its comprehensive
performance was the best. In addition,at the frequency of 1 kHz,the relative permittivity of the PDA-rGO
(0. 5 phr)/BIIR composites increased by 26%,and the capacitance responsivity to methanol and butanone
increased significantly,reaching 10. 7 and 79. 4,respectively. The PDA-rGO/BIIR composites were expected
to be used for the identification of some organic solvents. |
|
查看全文
查看/发表评论 下载PDF阅读器 |
关闭 |